AUTONET TV

Not-So-Common Sense (Sensor Failures)

So your vehicle won't start.  What's the first thing that comes to mind?  Battery dead? Starter motor worn out? Out of gas?  Well, those are all reasons that make sense.  But your vehicle may be refusing to start because one of its computers is being warned that to do so might damage it.  Here's how that works.

You have lots of computers in your vehicle.  They need to know the status of things so there are several sensors monitoring various things going on.  These sensors send information to the computers that adjust the fuel and air mixture so you don't waste fuel.  They know when things aren't quite right and prevent you from starting your engine if that's going to damage it. 

Other sensors make sure the coolant is the right temperature, check to see you are not polluting the air and make sure other electronic components are performing their tasks correctly.

Here's an example of a sensor doing its job.  Your engine needs oil to lubricate metal components so the friction doesn't damage them.  Your engine has an oil pressure sensor that tells a computer called the Electronic Control Unit (ECU) if things are good to go or if there's something wrong, maybe the oil pressure is too low to keep things lubricated.  If it is, it gives a signal for the vehicle not to start, protecting the engine. 

Of course, the sensors can go bad, too, with some of the same results.  And so someone has to figure out if it's the sensor that's failed or if it really has detected a problem.  That is the challenge for technicians with specialized equipment to decipher the signs.  If a bad sensor is found, it may need to be replaced.  Sometimes a thorough cleaning can do the trick.  In either case, your service facility can track down the problem and get you back on the road.  Makes sense, doesn't it?

Kingwood Service Center
3318 Northpark Dr
Kingwood, TX 77339
(281) 360-7323
www.kingwoodservicecenter.net

The Right Stuff (Choosing Replacement Parts)

Let's face it.  Vehicles are complicated machines, each having thousands of parts.  And since they're subjected to heat, cold, vibrations, bumps and much more, these parts wear out and need to be replaced. 

When your service advisor says you need a new part, you may have many options.  Let's say you need a new muffler.  One choice would be to get exactly the same part that was installed when the vehicle was manufactured.  The advantages are that it will perform the same way as the one it's replacing and will likely last about the same amount of time as the original.

Some mufflers are made by the same companies that supplied the automaker when your vehicle was new (they call that an OEM part—Original Equipment Manufacturer).  And often those are the same as the part you'd buy from a dealer. A reputable vehicle service facility will know which ones these are because they replace mufflers all the time and do their homework.

The good news is there are many different mufflers available from several manufacturers.  These are called aftermarket parts. Some of them may use different metals or a different construction technique. Some may sound a little sportier while some may make your engine perform better.  Your service advisor will discuss what your driving habits are and help choose the part that's best for you.

You may be able to get a part that's better than the one originally installed.  Here's an example.  A repair shop discovered one owner's vehicle had developed cracks and leaks in the hoses that attach to the heater core.  They were made of plastic, and heat and pressure had caused the originals to crack.  The service advisor recommended they replace it with an aftermarket part that was made of aluminum instead, one that was more durable than the original part.

Some aftermarket parts cost more, some cost about the same or less.  Depending on how and where you drive and what you want out of your vehicle, you can decide to buy more economical parts which might be the best fit for your needs.  Or you may decide to upgrade to a better, more expensive part.

Kingwood Service Center
3318 Northpark Dr
Kingwood, TX 77339
(281) 360-7323
www.kingwoodservicecenter.net

You Are the Fluid Detective! (Leaking Fluids)

When you see some liquid sitting underneath your vehicle, your mind starts churning.  Is that normal? Is that something serious, or did I just spill my drink? Here’s a quick list of what those fluids look, smell and feel like, as well as what they might be. No, we don’t recommend you taste them to verify.

   •    Clear and underneath your air conditioner or under the end of your tailpipe. It’s likely something as simple as condensed water.  This probably doesn’t need immediate attention, but you should keep checking periodically.
   •    Oily, brown, golden or black.  That could be the sign of engine oil leaking.  Oil may also smell if it has been leaking on metal and burning.  This is one you should have checked out fairly quickly.
   •    Green, blue, red, yellow, purple or orange and watery under the engine.  Smells sweet.  May be coolant (antifreeze) and a sign of a leaking radiator, hose or clamp.  Also, could mean your water pump is shot or radiator is broken or cracked.  The more that’s there, the more important it is for us to check it out soon.
   •    Yellow, slippery and smells a little foul.  Could be brake fluid. This is one that you should bring to us quickly to have us inspect.
   •    Red or pinkish and collects under the engine or middle of your vehicle.  Could be power steering fluid.  Here’s another one that should be checked by a professional soon.
   •    Red or brown liquid from around your transmission or between your radiator and the transmission, smells sweet.  You might smell burning from around your engine area, too.  Might be transmission fluid.  Another one where it’s important to have a pro look at it soon.  

Your eyes and nose can be helpful to spotting things that need attention on your vehicle.  When in doubt, head on over to see us so a technician can check it out.  Taking care of it sooner rather than later could save you an expensive repair down the road.

Kingwood Service Center
3318 Northpark Dr
Kingwood, TX 77339
(281) 360-7323
www.kingwoodservicecenter.net

U and your U-Joints (Lubricate U-Joints)

If your vehicle’s power goes to the rear wheels, then you have something called U-joints in the drivetrain. U-joints are connectors that allow the rotating power from your vehicle’s engine to deliver its power through a driveshaft to make the rear wheels rotate.  You need U-joints because the surfaces you drive on aren’t perfectly flat, and the driveshaft has to allow for some flexibility when you are traveling over uneven surfaces.

As you can imagine, the U-joints have to move and flex a lot as your vehicle is going down the road.  They have bearings in them to allow that flexibility, and those bearings are lubricated when your vehicle is made.  Some U-joints have lifetime lubrication and are not designed to be serviced.  When they fail, they have to be replaced.  Others have grease fittings on them that need periodic lubricating by a technician at intervals recommended by your vehicle’s manufacturer. 

There are signs you can look for that your U-joints need attention.  You may hear a clunk when the gears shift into drive or reverse.  You may feel your vehicle vibrate as you move down the road.  Other signs are leaks at the back of your transmission or a banging sound right before you lose power.  Sometimes, though, if you wait until you notice these symptoms, the U-joints may already be damaged.  

That’s why it’s important that your vehicle’s U-joints be periodically inspected and lubricated.  At the same time, a technician should thoroughly inspect the driveshaft and other connected components.  

Keep your U-joints in good shape, and both of U will continue to enjoy years of reliable transportation.

Kingwood Service Center
3318 Northpark Dr
Kingwood, TX 77339
(281) 360-7323
www.kingwoodservicecenter.net

Getting Off to a Running Start (Starter Replacement)

When you start your vehicle’s engine, there’s another motor that makes that whole process possible.  It’s called the starter, and it’s a small electric motor that gets your vehicle running.  

As you can imagine, it’s quite a chore for a little electric motor to turn over the big engine that powers your vehicle.  And after hundreds of successful starting missions, after a while, it will start to give out.

You’ll know the starter is starting to give up the ghost when it turns too slowly or sometimes doesn’t do anything when you turn on the ignition.  Maybe it makes funny noises like grinding when you try to start your vehicle or maybe there’s just a click. Those are all reasons to get your vehicle over to us so we can see what’s going on. 

A technician will make sure the problem is the starter and not in the battery, a switch, or other electrical component or connections.  If all of those are ruled out, your starter will be replaced.  The technician will also make sure all the cables and connections to the battery are clean and solid.  

Often starter problems come on gradually, and they often give you advanced warning that it’s time to have it fixed—before you find yourself frustrated— and stranded.

Kingwood Service Center
3318 Northpark Dr
Kingwood, TX 77339
(281) 360-7323
www.kingwoodservicecenter.net